參數資料
型號： RT9238CS
廠商： Electronic Theatre Controls, Inc.
元件分類： 基準電壓源/電流源
英文描述： VRM 8.5 PWM AND TRIPLE LINEAR POWER SYSTEM CONTROLLER
中文描述： VRM電源8.5脈寬調制和三線性電源系統控制器
文件頁數： 16/24頁
文件大?。?/td> 434K
代理商： RT9238CS
RT9238
Preliminary
www.richtek-ic.com.tw
16
DS9238-01 July 2001
elements. The voltage spikes can degrade efficiency,
radiate noise into the circuit, and lead to device over-
voltage stress. Careful component layout and printed
circuit design minimizes the voltage spikes in the
converter. Consider, as an example, the turn-off
transition of the upper MOSFET. Prior to turn-off, the
upper MOSFET was carrying the full load current.
During the turn-off, current stops flowing in the upper
MOSFET and is picked up by the lower MOSFET or
Schottky diode. Any inductance in the switched
current path generates a large voltage spike during
the switching interval. Careful component selection,
tight layout of the critical components, and short,
wide circuit traces minimize the magnitude of voltage
spikes.
There are two sets of critical components in a DC-DC
converter using an RT9238 controller. The switching
power components are the most critical because they
switch large amounts of energy, and as such, they
tend to generate equally large amounts of noise. The
critical small signal components are those connected
to sensitive nodes or those supplying critical bypass
current.
The power components and the controller IC should
be placed first. Locate the input capacitors, especially
the high-frequency ceramic de-coupling capacitors,
close to the power switches. Locate the output
inductor
and
output
capacitors
MOSFETs and the load. Locate the PWM controller
close to the MOSFETs.
between
the
The critical small signal components include the
bypass capacitor for VCC and the soft-start capacitor,
C
SS
. Locate these components close to their
connecting pins on the control IC. Minimize any
leakage current paths from any SS node, since the
internal current source is only 28
μ
A.
A multi-layer printed circuit board is recommended.
Fig.7 shows the connections of the critical
components in the converter. Note that the capacitors
C
IN
and C
OUT
each could represent numerous
physical capacitors. Dedicate one solid layer for a
ground plane and make all critical
component ground connections with vias to this layer.
Dedicate another solid layer as a power plane and
break this plane into smaller islands of common
voltage levels. The power plane should support the
input power and output power nodes. Use copper
filled polygons on the top and bottom circuit layers for
the PHASE node, but do not unnecessarily oversize
this particular island. Since the PHASE node is
subject to very high dV/dt voltages, the stray
capacitor formed between these island and the
surrounding circuitry will tend to couple switching
noise. Use the remaining printed circuit layers for
small signal wiring. The wiring traces from the control
IC to the MOSFET gate and source should be sized
to carry 2A peak currents.
Fig.7 Layout Planning
PWM1 Controller Feedback Compensation
The PWM controller uses voltage-mode control for
output
regulation.
compensation scheme is used with an active
capacitor and a passive resistor shown in Fig.8. The
zero FZ1 is fixed at about 1kHz to compensate the
output ‘s LC pole FLC. The compensation is to
An
internal
pole-zero
VCC
GND
OCSET
DRIVE2
UGATE
PHASE
LGATE
SS24
SS13
DRIVE3
DRIVE4
PGND
RT9238
L
L
L
L
L
IN
C
IN
+5V
IN
+12V
C
VCC
C
OCSET
+3.3V
IN
Q3
V
OUT2
C
OUT2
R
OCSET
Q1
L
OUT
V
OUT1
C
OUT1
CR1
Q2
V
OUT4
C
OUT4
Q5
Q4
C
OUT3
V
OUT3
C
SS24,13
ISLAND ON POWER PLANE LAYER
ISLAND ON CIRCUIT PLANE LAYER
VIA/THROUGH-HOLE CONNECTION TO GROUND PLANE
相關PDF資料
PDF描述
RTE135 Poly Switch PTC DEVICES
RTE190 Poly Switch PTC DEVICES
RTL8019AS Realtek Full-Duplex Ethernet Controller with Plug and Play Function (RealPNP)
RTL8168 INTEGRATED GIGABIT ETHERNET CONTROLLER FOR PCI EXPRESS TM
RUE250U Poly Switch PTC DEVICES
相關代理商/技術參數
參數描述
RT9241 制造商:未知廠家 制造商全稱:未知廠家 功能描述:Two-Phase DC/DC Controller for CPU Core Power Supply
RT9241A 制造商:未知廠家 制造商全稱:未知廠家 功能描述:
RT9241AGS 制造商:RICHTEK 制造商全稱:Richtek Technology Corporation 功能描述:Two-Phase DC/DC Controller for CPU Core Power Supply
RT9241APS 制造商:RICHTEK 制造商全稱:Richtek Technology Corporation 功能描述:Two-Phase DC/DC Controller for CPU Core Power Supply
RT9241B 制造商:未知廠家 制造商全稱:未知廠家 功能描述:
發布緊急采購，3分鐘左右您將得到回復。

采購需求

(若只采購一條型號，填寫一行即可)

發布成功！您可以繼續發布采購。也可以進入我的后臺，查看報價

發布成功！您可以繼續發布采購。也可以進入我的后臺，查看報價

*型號 *數量 廠商 批號 封裝
添加更多采購

我的聯系方式

*
*
*